Falcon (EA-AU)

1988-2002 / Sedan / Estate / Australia

All Falcon (EA-AU) problems All workshop issues

Common Suspension and Steering

AU Independent Rear Suspension (IRS) Bushing Wear

Symptoms

Clunking from the rear over bumps. Rear-end wander under braking. Uneven rear tyre wear.

Cause

The AU sedan's independent rear suspension uses rubber trailing arm bushings that wear with age and load.

Fix

Replace the rear trailing arm bushings.

This can be done without removing the subframe, but access is tight.

Cost: $200-400 per side fitted.

Cost mentioned in fix

Cost: $200-400 per side

Know something we don't?

Owned a Ford Falcon (EA-AU)? Share your experience with this issue. What worked, what didn't, costs, tips. Help the community.

Submit an update

// More Falcon (EA-AU) problems

Other known issues

Common Suspension and Steering

Front Lower Control Arm Bushings

Clunking over bumps, vague steering, uneven tyre wear on inner edges.

Common Suspension and Steering

Power Steering Pump Failure (AU)

Heavy steering, whining noise from the power steering pump, fluid leaks.

Critical Engine

TFI Module Failure (EA-ED)

The engine cuts out while driving and won't restart. After cooling for 30-60 minutes, it may restart and run normally for a while before dying again. Sometimes fails permanently.

Common Engine

Hydraulic Lifter Tick (AU especially, all models)

A ticking or tapping noise from the top of the engine, often worst on cold start. May persist for minutes or be constant. The noise comes from the rocker cover area.

Common Engine

Coil Pack Failure (EF-EL)

Misfiring on specific cylinders, rough idle, loss of power. May be intermittent initially, then become constant.

Critical Engine

Crank Angle Sensor Failure (EA-ED)

Engine cranks but won't start, or starts and dies. No spark at all cylinders.

View all 21 Falcon (EA-AU) problems